International Peer-Reviewed JournalOpen AccessISSN 2456-8880
irejournals@gmail.com+91-7433024337

Home / Current Issue / Paper 1713855

1713855 Vol 9 · Issue 7 Download Paper

Synthesis and Characterization of Thin Film Gas Sensors Using Sri Lankan Natural Graphite: Comparative Analysis of Sensitivity to Ammonia, Acetone, and Ethanol Vapors

Ilukkumbure Gedara Prishantha Neel Karunasena Chathuranga Rathnayake Roshan Thotagamuge S.P.A.U.K. Samarakoon P. Samarasekara

Subject area: Science,Engineering and Technology  ·  Area of research: Material and sensors

DOI: https://doi.org/10.64388/IREV9I7-1713855

Abstract

Gas sensors were synthesized by using Sri Lankan natural graphite as the primary material. Any kind of pure graphite has never been used to identify ammonia, acetone and ethanol vapors. A thin film was coated on Fluorine-doped Tin Oxide (FTO) glass using the doctor blade method, with the graphite mixture prepared using acetone and distilled water and annealed at 100 0C for two hours in air. Surface morphology analysis via Scanning Electron Microscopy (SEM) revealed closely packed irregular shaped particles ranging in size from approximately 4 to 70 μm. The estimated value of the porosity was found to be 8.98%. X-ray Diffraction (XRD) analysis explored calculated crystallite sizes of 60.00782, 73.19767, and 59.28573 nm for the 002, 004, and 006 planes, respectively. X-ray diffraction patterns reveal that single phase of pure graphite is crystallized in thin film form, and there is not any preferred orientation of crystallites. Gas sensitivity, recovery time, and response time were evaluated in 1000 ppm of ammonia (NH3), ethanol, and acetone vapors at room temperature. Among these, acetone vapor exhibited the highest sensitivity at 23.98% for 1000 ppm, compared to 6.37% for NH3 and 7.16% for ethanol. The response and recovery times for acetone vapor were 50 and 22 minutes, respectively. All the samples were measured for three adsorption and desorption cycles to study the repetition of data. The saturated voltage of the sample after adsorbing the gas slightly increases in each cycle with the time for each vapor.

Keywords

Sri Lankan Graphite; Gas Sensors; Gas Sensitivity; Doctor Blade Method

References

[1] Aladekomo, J. B., and Bragg, R. H. (1990). STRUCTURAL TRANSFORMATIONS INDUCED IN GRAPHITE BY GRINDING: ANALYSIS OF 002 X-RAY DIFFRACTION LINE PROFILES. Carbon 28(6): 897-906.

[2] Bannov, A. G., Prášek, J., Jašek, O., Shibaev, A. A., and Zajíčková, L. (2016). Investigation of Ammonia Gas Sensing Properties of Graphite Oxide. Procedia Engineering 168: 231–234. https://

[3] Barnakov, C. N., Khokhlova, G. P., Popova, A. N., Sozinov, S. A., and Ismagilov, Z. R. (2015). XRD characterization of the structure of graphites and carbon materials obtained by the low-temperature graphitization of coal tar pitch. Eurasian Chemico-Technological Journal 17(2): 87–93. https://

[4] Chachuli, S. A. M., Noor, M. L. H., Coban, O., Shamsudin, N. H., and Idris, M. I. (2023). Characteristic of graphene-based thick film gas sensor for ethanol and acetone vapor detection at room temperature. Indonesian Journal of Electrical Engineering and Computer Science 32(3): 1384 –1391. https:// 4-1391

[5] Chakraborthy, A., Nuthalapati, S., Nag, A., Afsarimanesh, N., Alahi, M. E. E., and Altinsoy, M. E. (2022). A Critical Review of the Use of Graphene-Based Gas Sensors. Chemosensors 10(9): 355. https://

[6] Han, J. W., Kim, B., Li, J., and Meyyappan, M. (2014). A carbon nanotube based ammonia sensor on cellulose paper. RSC Advances 4(2): 549–553. https://

[7] Li, Z. Q., Lu, C. J., Xia, Z. P., Zhou, Y., and Luo, Z. (2007). X-ray diffraction patterns of graphite and turbostratic carbon. Carbon 45(8): 1686–1695. https://

[8] Li, C., Choi, P. G., Kim, K., and Masuda, Y. (2022). High performance acetone gas sensor based on ultrathin porous NiO nanosheet. Sensors and Actuators B: Chemical 367. 132143.https:// 143

[9] Li, C., Kim, K., Fuchigami, T., Asaka, T., Kakimoto, K., and Masuda, Y. (2023). Acetone gas sensor based on Nb2O5 @SnO2 hybrid structure with high selectivity and ppt-level sensitivity. Sensors and Actuators B: Chemical 393: 134144. https://

[10] Liao, W. Z., Dai, C. L., and Yang, M. Z. (2013). Micro ethanol sensors with a heater fabricated using the commercial 0.18 μm CMOS process. Sensors 13(10): 12760 –12770. https://

[11] Liu, F., Chu, X., Dong, Y., Zhang, W., Sun, W., and Shen, L. (2013). Acetone gas sensors based on graphene-ZnFe2O4 composite prepared by solvothermal method. Sensors and Actuators B: Chemical 188: 469 –474. https://

[12] Manzoli, A., Steffens, C., Paschoalin, R.T., Correa, A.A. , Alves, W.F. , Leite, F.L., Herrmann, P.S.P. (2011). Low-Cost Gas Sensors Produced by the Graphite Line- Patterning Technique Applied to Monitoring Banana Ripeness. Sensors 11(6): 6425-6434.

[13] Pandya H.J., Chandra S., and Vyas A.L. (2011). Fabrication and Characterization of Ethanol Sensor Based on RF Sputtered ITO Films. Sensors & Transducers Journal 10:141–150.

[14] Popova, A. N. (2017). Crystallographic analysis of graphite by X-Ray diffraction. Coke and Chemistry 60(9): 361 –365. https://

[15] Qiu, T., Yang, J., Bai, X., and Wang, Y. (2019). The preparation of synthetic graphite materials with hierarchical pores from lignite by one-step impregnation and their characterization as dye absorbents. RSC Advances 9(22): 12737–12746. https://

[16] Ranasinghe, R.A.S.R., Rathnathilaka, K.A.C., Karunarathna, P.G.D.C.K. and Samarasekara, P. (2024). Carbon gas sensors synthesized using acacia auriculiformis tree branches to detect methanol, ethanol, acetone vapors and ammonia gas. Ceylon Journal of Science 53(2): 207-218. https://

[17] Samarahewa, C.A., Dehipawala, S. and Samarasekara P. (2024). Optimization of gas sensitivity of CuO/carbon composites with carbon particles synthesized from acacia auriculiformis branches. STM Journals: International Journal of Membranes 1(1): 22- 30.

[18] Travlou, N. A., Seredych, M., Rodriguez- Castellon, E., and Bandosz, T. J. (2014). Activated carbon-based gas sensors: Effects of surface features on sensing mechanism. Journal of Materials Chemistry A 3: 3821-3831. https:// 61F

[19] Yang, L.P., Cheng, W., Yan, W., Wen, L., Xia, C., Sun, C., Hu D., Zhao, Y., Guo, X., Zeng W. and Wang S. (2024). Highly Sensitive and Selective MEMS Gas Sensor Based on WO3/Al2O3/Graphite for 2-Chloroethyl Ethyl Sulfide (2-CEES) Detection. Chemosensors 12(1):5 https://

[20] Yi, M., Shen, Z., Zhang, X., and Ma, S. (2012). Achieving concentrated graphene dispersions in water/acetone mixtures by the strategy of tailoring Hansen solubility parameters. Journal of Physics D: Applied Physics 46: 025301 https://

[21] Zhang, R., Wang, Y., Zhang, Z., and Cao, J. (2018). Highly sensitive acetone gas sensor based on g-C3N4 decorated MgFe2O4 porous microspheres composites. Sensors 18(7): 2211. https://

[22] Zhou, H., Ramaraj, S. G., Ma, K., Sarker, M. S., Liao, Z., Tang, S., Yamahara, H., and Tabata, H. (2023). Real-time detection of acetone gas molecules at ppt levels in an air atmosphere using a partially suspended graphene surface acoustic wave skin gas sensor. Nanoscale Advances 5(24): 6999 –7008. https://

How to cite this paper

Ilukkumbure Gedara Prishantha Neel Karunasena, Chathuranga Rathnayake, Roshan Thotagamuge, S.P.A.U.K. Samarakoon, P. Samarasekara "Synthesis and Characterization of Thin Film Gas Sensors Using Sri Lankan Natural Graphite: Comparative Analysis of Sensitivity to Ammonia, Acetone, and Ethanol Vapors" Iconic Research And Engineering Journals Volume 9 Issue 7 2026 Page 2244-2252 https://doi.org/10.64388/IREV9I7-1713855
Ilukkumbure Gedara Prishantha Neel Karunasena, Chathuranga Rathnayake, Roshan Thotagamuge, S.P.A.U.K. Samarakoon, P. Samarasekara "Synthesis and Characterization of Thin Film Gas Sensors Using Sri Lankan Natural Graphite: Comparative Analysis of Sensitivity to Ammonia, Acetone, and Ethanol Vapors" Iconic Research And Engineering Journals, vol. 9, no. 7, Jan. 2026, doi: https://doi.org/10.64388/IREV9I7-1713855
Ilukkumbure Gedara Prishantha Neel Karunasena, Chathuranga Rathnayake, Roshan Thotagamuge, S.P.A.U.K. Samarakoon, P. Samarasekara (2026). Synthesis and Characterization of Thin Film Gas Sensors Using Sri Lankan Natural Graphite: Comparative Analysis of Sensitivity to Ammonia, Acetone, and Ethanol Vapors. Iconic Research And Engineering Journals, 9(7). doi: https://doi.org/10.64388/IREV9I7-1713855
Ilukkumbure Gedara Prishantha Neel Karunasena, Chathuranga Rathnayake, Roshan Thotagamuge, S.P.A.U.K. Samarakoon, P. Samarasekara "Synthesis and Characterization of Thin Film Gas Sensors Using Sri Lankan Natural Graphite: Comparative Analysis of Sensitivity to Ammonia, Acetone, and Ethanol Vapors" Iconic Research And Engineering Journals, vol. 9, no. 7, Jan. 2026. Crossref, https://doi.org/10.64388/IREV9I7-1713855
@article{1713855,
      author = {Ilukkumbure Gedara Prishantha Neel Karunasena, Chathuranga Rathnayake, Roshan Thotagamuge, S.P.A.U.K. Samarakoon, P. Samarasekara},
      title = {Synthesis and Characterization of Thin Film Gas Sensors Using Sri Lankan Natural Graphite: Comparative Analysis of Sensitivity to Ammonia, Acetone, and Ethanol Vapors},
      journal = {Iconic Research And Engineering Journals},
      year = {2026},
      volume = {9},
      number = {7},
      pages = {2244-2252},
      issn = {2456-8880},
      url = {https://www.irejournals.com/formatedpaper/1713855.pdf},
      abstract = {Gas sensors were synthesized by using Sri Lankan natural graphite as the primary material. Any kind of pure graphite has never been used to identify ammonia, acetone and ethanol vapors. A thin film was coated on Fluorine-doped Tin Oxide (FTO) glass using the doctor blade method, with the graphite mixture prepared using acetone and distilled water and annealed at 100 0C for two hours in air. Surface morphology analysis via Scanning Electron Microscopy (SEM) revealed closely packed irregular shaped particles ranging in size from approximately 4  to 70 μm. The estimated value of the porosity was found to be 8.98%. X-ray Diffraction (XRD) analysis explored calculated crystallite sizes of 60.00782, 73.19767, and 59.28573 nm for the 002, 004, and 006 planes, respectively. X-ray diffraction patterns reveal that single phase of pure graphite is crystallized in thin film form, and there is not any preferred orientation of crystallites. Gas sensitivity, recovery time, and response time were evaluated in 1000 ppm of ammonia (NH3), ethanol, and acetone vapors at room temperature. Among these, acetone vapor exhibited the highest sensitivity at 23.98% for 1000 ppm, compared to 6.37% for NH3 and 7.16% for ethanol. The response and recovery times for acetone vapor were 50 and 22 minutes, respectively. All the samples were measured for three adsorption and desorption cycles to study the repetition of data. The saturated voltage of the sample after adsorbing the gas slightly increases in each cycle with the time for each vapor.},
      keywords = {Sri Lankan Graphite; Gas Sensors; Gas Sensitivity; Doctor Blade Method},
      month = {January},
      doi = {https://doi.org/10.64388/IREV9I7-1713855}
  }